Filter Fibers and Media for Hot Gas Filtration Will Be Discussed and Compared At
AFS Coal Charlotte, April 28-29, 2015
Should you use PPS, P84, fiberglass or some other fiber? Should you use
laminates with membrane films. What is the advantage of tailored fiber
combinations of nonwovens? Are the sewing holes large enough to cause
compliance problems with the 5 mg/Nm3 limits? What about a radical
choice of an 850oF ceramic element with embedded catalyst coupled
with heat recovery to reduce greenhouse gases? All these subjects will be
addressed at the conference. Bob McIlvaine will be chairing a Q and A
session to probe the issues. If you have information to contribute or just
want to participate, email:
rmcilvaine@mcilvainecompany.com, for details on the
conference, click on:
http://www.afssociety.org/.
Coal-fired Power Plants around the World Are Switching to Fabric Filters
A small percentage of coal-fired power plants use fabric filters. Most utilize
precipitators. However, tough new regulations in all the regions of the
world are creating a big market for fabric filters. They will be used on many
new boilers as well as being retrofitted into existing power plants. In
many instances the bags are installed in the existing precipitator casing.
The market is regulatory driven. The extent of the switch in the U.S. and China
will have the biggest impact. This is the conclusion reached by McIlvaine
in
World Fabric Filter and Element Market.
(www.mcilvainecompany.com)
The 2017 market for coal-fired boiler fabric filter systems could be as small as
$1.5 billion or as large as $5 billion. The total market for fabric filter
systems could be as low as $8.5 billion or as large as $12 billion.
World Fabric Filter System
Revenues 2017 ($ Millions) |
||
Application |
Minimum |
Maximum |
Industrial |
7,000 |
7,000 |
Coal-fired Utility Power |
1,500 |
5,000 |
Total |
8,500 |
12,000 |
The two largest variables are:
·
Compliance with stringent particulate emission standards
·
Competition from wet precipitators and upgraded dry precipitators
Both the U.S. and China have tough new standards which will be difficult to meet
with existing dry precipitators. The use of wet precipitators downstream
of the existing dry precipitators will provide the required efficiency. However,
fabric filters provide an equally efficient and, in most cases, a lower cost
solution. This is particularly true when the existing precipitator casing
can be used.
Traditionally, the U.S. and Australia were the main proponents of fabric
filters. Now Italy, Russia, China and Chile are among the countries utilizing
fabric filters for their coal-fired boilers. South Africa has a very large
retrofit program.
For more information on
World Fabric Filter and Element Market,
click on:
http://home.mcilvainecompany.com/index.php/markets/2-uncategorised/110-n021
FABRIC FILTER NEWSLETTER HEADLINES
January 2015
MARKETS
STEEL
GASIFICATION
MINING
COMPANY NEWS
REGULATIONS
ENFORCEMENT ACTIONS
The Fabric Filter Newsletter is included in two services:
World Fabric Filter and Element Market,
click on:
http://home.mcilvainecompany.com/index.php/markets/2-uncategorised/110-n021
Fabric Filter Knowledge System,
click on:
http://home.mcilvainecompany.com/index.php/other/2-uncategorised/95-1abc
PRECIP NEWSLETTER HEADLINES
December 2014
HOT TOPIC HOURS
COAL-FIRED BOILERS
COPPER
COMPANY NEWS
RESEARCH
For more information on Electrostatic Precipitators: World Market click
on:http://home.mcilvainecompany.com/index.php/markets/2-uncategorised/111-n018
OIL & GAS SALES LEADS HEADLINES
January 23, 2015
Oil and Gas Project Tracking is available at a discount to Electrostatic
Precipitators: World Market
or World Fabric Filter and Element
Market
subscribers.
Treatment chemicals are an important addition to most oil and gas processes.
Access to details on worldwide oil and gas projects is provided at a substantial
discount to Electrostatic Precipitators: World Market or World Fabric
Filter and Element Market subscribers.
(Listed by most current date)
Oil Spills in Yellowstone River after Pipeline Leak
Revision Date: 1/23/2015
More than $150 Bln of Oil Projects Could be Deferred in 2015
Revision Date: 1/23/2015
Enterprise to Move Forward with Panola NGL Pipeline Expansion
Revision Date: 1/23/2015
Energy Transfer Partners and Regency Energy Partners to Construct Third
Fractionation Facility at Mont Belvieu
Revision Date: 1/23/2015
Riskiest Oil Fields Affected by Plunging Oil Prices Crippling Future Growth
Revision Date: 1/22/2015
STW Water Demonstrates Its Salttech Water Reclamation Technology
Revision Date: 1/22/2015
Status of U.S. Gulf of Mexico Deepwater Discoveries
Revision Date: 1/20/2015
Canadian Natural Resources Defers Kirby Oil Sands Thermal Project
Revision Date: 1/19/2015
In Situ Oilsands Production Reaches Record High in October
Revision Date: 1/16/2015
Oil's Plunge Threatens Suncor's Fort Hills Development
Revision Date: 1/16/2015
Canada’s Oil-Sands Operators Dig in for Long Haul as Oil Prices Go Below $50
Revision Date: 1/16/2015
ICA Fluor to Build Delayed Coker at Pemex Hidalgo Refinery
Revision Date: 1/16/2015
The Other Oil Sands Fight in Utah with Possible Solution to Lower Environmental
Impact
Revision Date: 1/16/2015
Emerson Awarded $27 Mln Contract to Automate Long Lake Oil Sands Project
Revision Date: 1/15/2015
Oilsands Lead not seeping into Rivers According to University of Alberta Lab
Tests
Revision Date: 1/15/2015
Canada’s Oil Sands Industry Goes on Offensive after Facing Escalating Pushback
Revision Date: 1/15/2015
Kearl Oilsands Project to Suspend Output for Several Weeks after Malfunction
Revision Date: 1/15/2015
New Alberta Oil Sands $1.3 Bln Contract Awarded to Fluor Corp
Revision Date:
1/15/2015
EU Vote Puts Canadian Tar Sands Label Back on the Agenda
Revision Date: 1/15/2015
Oil sands Tailings Ponds Emit Pollutants into the Air, Study Confirms
Revision Date: 1/15/2015
Canada Sticks to its Line on the Oil Sands at UN Climate Summit
Revision Date: 1/14/2015
Canada’s Oil Sands Producers Promise Steps to Cut Pollution
Revision Date: 1/14/2015
Cenovus Gets Approval for Alberta Telephone Lake Oil Sands Project
Revision Date: 1/14/2015
ICA Fluor Awarded Fabrication Contract for Shell's Carmon Creek Heavy Oil
Extraction Project
Revision Date: 1/14/2015
Iran to Inaugurate Petrochemical Plant in Its Northwest
Revision Date: 1/13/2015
Saudi Arabia to Invest $91 Bln to Spur Petrochemical Industry
Revision Date: 1/13/2015
BMI Report Says Malaysia Petrochemicals Capacity to Undergo Major Increase
Revision Date: 1/13/2015
Report Says Iran to Triple Petrochemical Production to 180Mln Tons by 2022
Revision Date: 1/12/2015
Petkim to Float Paraxylene Tenders in January after 6 Months Gap
Revision Date: 1/12/2015
Iran to Resume Exporting Petrochemicals after U.S. Ban
Revision Date: 1/12/2015
Propylene Unit Reaches Capacity in Russia due to UOP C3 Oleflex™ Process
Technology
Revision Date: 1/12/2015
Alfa Laval Wins Heat Exchanger Order for South Korea Petrochemical Plant
Revision Date: 1/12/2015
U.S. Chemical Industry Set to Outpace Overall Economic Growth
Revision Date: 1/9/2015
Chevron Phillips Completes Sweeny Ethylene Expansion
Revision Date: 1/9/2015
China Commissions UOP C3 Oleflex™ Process Technology for Propylene Unit
Revision Date: 1/8/2015
Sasol Announces Financing Milestone for Louisiana Project
Revision Date: 1/8/2015
Japan to Shut Four Naphtha Crackers for 2015 Turnaround
Revision Date: 1/8/2015
Vietnam to Grant License for $22 Bln Refinery, Petchem Complex Early in 2015
Revision Date: 1/8/2015
Versalis Inks Agreement to Transfer Sarroch Plants in Sardinia to Sarlux
Revision Date: 1/7/2015
Etileno XXI Plant Could Revive Mexico's Petrochemical Sector
Revision Date: 1/7/2015
Asia Key Driver in Qatar Petrochemicals Expansion
Revision Date: 1/7/2015
Saudi's Yansab to Shut Ethylene Glycol Plant in April for Maintenance
Revision Date: 1/6/2015
Weatherford Sells Chemicals, Drilling Fluids Units to Lubrizol for $750 Mln
Revision Date: 1/6/2015
Ineos, Sasol Break Ground on Texas HDPE Project
Revision Date: 1/6/2015
German Chemicals Sector Sees 1.5 Pct Sales Growth in '14 and '15
Revision Date: 1/6/2015
Linde Installs Gasifier Vessel at Texas Facility
Revision Date: 1/6/2015
Chevron Phillips Says Petchem Industry Should Enhance Connectivity with Social
Media
Revision Date: 1/6/2015
India's BPCL to Invest Over $741 Mln in Petrochemicals Business
Revision Date: 1/6/2015
Westlake Chemical to Add Ethylene Capacity in Lake Charles
Revision Date: 1/5/2015
Saudi's SABIC, Shell Shelve Petchem Plant Expansion in Jubail
Revision Date: 1/5/2015
Dow Chemicals to Cut $1 Bln in Costs Over 3 Years
Revision Date: 1/5/2015
North Dakota Group, Badlands NGL Plans $4 Bln Chemical Plant
Revision Date: 1/5/2015
Chemtura Expands Antioxidant Capacity for Auto Industry Demand Growth
Revision Date: 1/5/2015
U.S. Manufacturing Exports Surging due to Shale Gas
Revision Date: 1/5/2015
Ineos Plans $1 Bln Investment in UK Shale Gas Exploration
Revision Date: 1/5/2015
Sasol Gives Go-ahead to $8.1 Bln U.S. Ethane Cracker
Revision Date: 1/5/2015
Louisiana Ethane Cracker Project Goes to Fluor-Technip JV
Revision Date: 1/4/2015
Petchems Are Benefiting from Cheap Feedstocks
Revision Date: 1/4/2015
Gulf Coast Growth Spurs Demand for Cleaning, Environmental Services
Revision Date: 1/4/2015
Williams Partners Louisiana Plant Should Start Producing Ethylene in November
Revision Date: 1/3/2015
Catalytic Processes Could Yield Alternatives to Refineries, Ethane Crackers
Revision Date: 1/3/2015
European Petchem Group's Re-branding: More Than A New Name
Revision Date: 1/3/2015
BG Group’s Queensland Curtis LNG Second Train on Track
Revision Date: 1/2/2015
Bechtel Completes Milestone Module Program for Curtis Island LNG Projects
Revision Date: 1/2/2015
BG Group Loads First Coal-seam-gas to LNG Cargo from QCLNG Project in Australia
Revision Date: 1/2/2015
Venture Global LNG Announces Calcasieu Pass Export Facility in Southwestern
Louisiana
Revision Date: 1/2/2015
Freeport LNG Closes Financing, Begins Construction of Initial Two Liquefaction
Trains
Revision Date: 1/1/2015
LNG Canada Selects GE Oil & Gas LMS100 Gas Turbine-Compressor Technology for
Proposed Kitmat Facility
Revision Date: 1/1/2015
Canadian Aboriginal Group Signs $5.3 Mln Deal to Support LNG Pipeline
Revision Date: 1/1/2015
Eni Signs Small-scale LNG Deal with Skangass
Revision Date: 1/1/2015
Santos Reassures on Costs at $18.5 Bln Gladstone LNG Project
Revision Date: 1/1/2015
Freeport LNG Receives Final FERC and DOE Approvals
Revision Date: 12/31/2014
Pacific Connector Gas Pipeline Receives Draft Environmental Impact Statement
Revision Date: 12/31/2014
5th and final installment: Exclusive Platts Series on China’s Shandong “Teapot”
Oil Refineries
Revision Date: 12/31/2014
Air Products to Work with Technip on Inner Mongolia LNG Project
Revision Date: 12/31/2014
Dominion Begins Construction Activities for Cove Point LNG Export Project
Revision Date: 12/31/2014
Applied LNG Announces Midlothian LNG Plant Groundbreaking
Revision Date: 12/31/2014
For more information on Oil, Gas, Shale and Refining Markets and Projects
click on:
http://home.mcilvainecompany.com/index.php/markets/28-energy/471-n049
World Fabric Filter and Element Market,
click on:
http://home.mcilvainecompany.com/index.php/markets/2-uncategorised/110-n021
For more information on Electrostatic Precipitators: World Market click
on:
http://home.mcilvainecompany.com/index.php/markets/2-uncategorised/111-n018
WORLD POWER GENERATION PROJECTS
HEADLINES
This includes only projects where there was an update during the month.
There are thousands of projects in the database.
New power generation projects are tracked in two publications. Fossil and
Nuclear Power Generation includes both market forecasts and project data.
World Power Generation Projects has just the project data.
START-UP DATE: Online
Location |
Location
Comment |
Project Title |
AL |
West Jefferson Co. |
J.H. Miller 4-Alabama Power |
AL |
West Jefferson Co. |
J.H. Miller 3-Alabama Power |
AZ |
Springerville |
Springerville 2-Alamito Co. |
CA |
Bakersfield |
Constellation/Ultrasystems 1
|
CA |
Bakersfield |
Constellation/Ultrasystems 2
|
Canada |
Alberta, Genesee |
Genesee 1-Edmonton Power |
Canada |
Alberta, Genesee |
Genesee 2-Edmonton Power |
Canada |
Nova Scotia, Trenton |
Trenton 6-Nova Scotia Power |
Finland |
Seinajoki |
|
France |
|
Electricite de France |
GA |
Forsyth |
Scherer 4-Georgia Power |
Germany |
|
Wilhelm Pieck 5 Jaenschwalde
|
Germany |
|
Wilhelm Pieck 1 Jaenschwalde
|
Germany |
|
Wilhelm Pieck 2 Jaenschwalde
|
Germany |
|
Wilhelm Pieck 3 Jaenschwalde
|
Germany |
|
|
Germany |
|
Wilhelm Pieck 6 Jaenschwalde
|
Germany |
West Berlin |
Moabit-Bewag/Berlin |
IN |
Rockport |
|
India |
Bombay |
|
Indonesia |
near Jakarta |
Cikarang Industrial Estate
power plant expansion |
Indonesia |
West Java, Ciligon |
Suralaya 1 Perusahaan Umum
Listrik Negara |
Indonesia |
West Java, Ciligon |
Suralaya 2 Perusahaan Umum
Listrik Negara |
Kenya |
|
Nairobi diesel plant |
KY |
Trimble Co. Bedford |
|
LA |
|
Willow Glen 3-Gulf States
Utilities |
MD |
Anne Arundel Co. |
Brandon Shores 2-Baltimore Gas
& Electric |
NC |
|
Buxton 1-5-North Carolina Elec.
Mem. Corp. |
OH |
Moscow |
Zimmer 1-Cincinnati Gas &
Electric |
Philippines |
Calaca |
Calaca-National Power Corp. |
Taiwan |
Taichung Harbor |
|
Taiwan |
Taichung Harbor |
Taichung Harbor 2-Taiwan Power |
Thailand |
Lampang |
Mae Moh 9-EGAT |
TX |
Robertson Co. Hammond/Calvert |
TNP One 1-Texas/New Mexico
Power |
TX |
Robertson Co. Hammond/Calvert |
TNP One 2-Texas/New Mexico
Power |
WI |
Port Washington |
Port Washington 4-Wisconsin
Electric Power |
WI |
Port Washington |
Port Washington 1-Wisconsin
Electric Power |
WI |
Port Washington |
Port Washington 3-Wisconsin
Electric Power |
For more information on World Power Generation Projects, click on:
http://home.mcilvainecompany.com/index.php/databases/28-energy/486-40ai
-------
You can register for our free McIlvaine Newsletters at:
http://www.mcilvainecompany.com/brochures/Free_Newsletter_Registration_Form.htm.
Bob McIlvaine
President
847-784-0012 ext 112
rmcilvaine@mcilvainecompany.com
www.mcilvainecompany.com